Chimney stacks are the most maintenance-intensive part of any pitched roof. We repoint, reflash and rebuild stacks across the full coverage area. Covering Catterick, Richmond and the surrounding area.
Chimney stacks are the most maintenance-intensive part of any pitched roof. We repoint, reflash and rebuild stacks across the full coverage area. Chimney repointing from £250. Lead flashing from £350.
Raking out and repointing deteriorated mortar joints. Lime or cement mortar matched to the property age and type.
Full lead flashing replacement at chimney abutments using Code 4 and Code 5 lead sheet.
Partial and full stack rebuilding where frost or settlement has caused structural deterioration.
Replacement of the mortar cap around chimney pots — a common source of water entry.
Supply and fit of replacement pots and capping for unused flues.
Mid-terrace chimney work addressing the full shared stack.
Catterick is a substantial village with a mix of Victorian and Edwardian stone properties in the original village core, significant post-war and modern development on the fringes associated with the nearby garrison, and 1960s–80s residential estates with concrete interlocking tile. Understanding the specific roof types and their failure patterns is what separates a roofer who gets it right first time from one who guesses.
Vale of Mowbray location with open exposure from the north and west. The Swale Valley provides some shelter for lower-lying properties but higher ground around the village fringe faces significant wind exposure affecting mortar bedding life. This directly affects maintenance frequency and which repair approaches last longest.
Nail sickness on post-war and 1960s–80s garrison-era housing; mortar ridge failure on exposed pitches; lead flashing deterioration on older village centre properties; natural slate maintenance on Victorian stone properties. We cover Catterick regularly from our Darlington base and carry the most common materials on the vehicle.
Chimney repointing from £250. Lead flashing from £350. No call-out fee.
“Re-roof on our 1970s garrison-era semi. Dry-fix ridge and new breathable felt as standard. Nail sickness had been spreading for years.”
“Victorian stone property in the village centre — matching Welsh slate for a difficult hip repair. Correct job done properly.”
“Emergency after storm. Responded quickly and made the roof safe the same evening. Permanent repair the following morning.”
Realistic 2025 prices for Catterick properties. All quotes are free, written and itemised before work begins.
| Job Type | Typical Cost |
|---|---|
| Chimney repointing (full stack) | £250–£600 |
| Flaunching replacement | £150–£350 |
| Lead flashing replacement | £350–£700 |
| Chimney pot replacement | £100–£250 per pot |
| Partial stack rebuild | £600–£1,500 |
| Scaffold (chimney work) | £400–£800, included |
All prices are installed costs. Call 01325 000 000 for a free written quote.
All chimney work in Catterick starts with a scaffold-accessed inspection of the full stack — not a ground-level look with binoculars. From scaffold we inspect mortar joints, flaunching condition, lead flashing at all abutments, pot and terminal condition, and any visible cracking in the brickwork. Nail sickness on post-war and 1960s–80s garrison-era housing, mortar ridge failure on exposed pitches, lead flashing deterioration on older village centre properties. An accurate diagnosis from scaffold level means the work quoted is the work that's actually needed rather than a conservative estimate covering unknowns we haven't looked at.
The decision between repointing and rebuilding a chimney stack in Catterick depends on the structural integrity of the brickwork. Repointing is appropriate when the bricks are sound and only the mortar joints have eroded. Rebuilding is required where frost action has spalled the brick faces, where settlement or movement has cracked the stack, or where the mortar has eroded so deeply that the bricks themselves have shifted position. Substantial village with victorian and edwardian stone properties in the original village core in Catterick — the older the stack the more likely rebuilding is appropriate on the upper section even if the lower section is sound.
Lead at chimney abutments in Catterick faces the specific stress of vale of mowbray location with open exposure from the north and west — higher ground around the village fringe faces significant wind exposure affecting mortar bedding life. Correctly installed lead with proper clips and expansion allowance handles this movement without cracking. The failures we see on Catterick properties are almost always installation defects — lead fixed too rigidly, or installed in Code 3 when Code 4 or 5 is required. We use Code 4 for soakers and step flashings, Code 5 for cover flashings, and form all bays to BS 6915 lengths to accommodate thermal movement.
Yes. Any contractor offering to repoint a chimney from a ladder is working unsafely and without adequate insurance. Scaffold is included in our chimney repair quotes.
It depends on the age and type of the stack. Victorian and older stone properties should be repointed with lime mortar matching the original — using hard cement mortar on older brickwork causes the bricks to crack rather than the mortar joint. We match the specification to the stack.
Yes. An uncapped unused chimney lets rain in directly, saturating the internal brickwork and causing damp patches on interior walls. We fit capping pots that prevent water entry while maintaining ventilation through the flue.
Yes. We're registered with the National Federation of Roofing Contractors, meeting recognised industry standards for quality and safety. All work comes with a written 10-year workmanship guarantee.
Yes. All quotes are free, no-obligation and provided in writing. We get on the roof to measure and inspect before quoting — no estimates from the street, no call-out charge for the survey visit.
We cover Darlington and approximately a 20-mile radius including Stockton-on-Tees, Middlesbrough, Newton Aycliffe, Bishop Auckland, Northallerton, Yarm, Eaglescliffe, Barnard Castle, Richmond and all surrounding villages.
Yes. We carry £5m public liability insurance on all work and are happy to provide evidence of cover before starting any job.
No call-out fee. 17 miles from Darlington — typically 25 minutes.
01325 000 000